Nissan Frontier Front Leveling Kit NL221 User Manual download pdf

2265 Crosswind Drive • Prescott, AZ 86301

(928) 636-3175 • www.p-a-g.net

NISSAN FRONTIER

FRONT LEVELING KIT

INSTALLATION INSTRUCTIONS

2005-2006 KIT# NL221

WARNING

Installation of a Performance Automotive Group sus-

pension lift kit will change the vehicle’s center of gravity

and handling characteristics both on- and off-road. You

must drive the vehicle safely! Extreme care must be

taken to prevent vehicle rollover or loss of control,

which could result in serious injury or death. Avoid sud-

den sharp turns or abrupt maneuvers and always make

sure all vehicle occupants have their seat belts fas-

tened.

WARNING

Before you install this kit, read and understand all

instructions, warnings, cautions, and notes in this

instruction sheet and in the vehicle owner’s manual.

CAUTION

Proper installation of this kit requires knowledge of the

factory recommended procedures for removal and

installation of original equipment components. We rec-

ommend that the factory shop manual and any special

tools needed to service your vehicle be on hand during

the installation. Installation of this kit without proper

knowledge of the factory recommended procedures

may affect the performance of these components and

the safety of the vehicle. We strongly recommend that

a certified mechanic familiar with the installation of sim-

ilar components install this kit.

WARNING

This kit should only be installed on a vehicle that is in

good working condition. Before you install the kit, thor-

oughly inspect the vehicle for corrosion or deformation

of the sheet metal. If the vehicle is suspected to have

been in a collision or misused, do not install this kit.

Off-road use of your vehicle with this kit installed may

increase the stress applied to the factory components.

Failure to observe this warning may result in serious

personal injury and/or severe damage to your vehicle.

WARNING

Many states and municipalities have laws restricting

bumper heights and vehicle lifts. Consult state and

local laws to determine if the changes you intend to

make to the vehicle comply with the law.

WARNING

The installation of larger tires may reduce the effective-

ness of the braking system.

WARNING

Always wear eye protection when operating power

tools.

WARNING

Before you install this kit, block the vehicle tires to pre-

vent the vehicle from rolling.

NOTE

Performance Automotive Group recommends using

the Loctite® supplied in the kit on the threads of all kit

nuts and bolts unless specified otherwise in these

instructions.

NOTE

Installation of a suspension lift will change the driveline

angles which may cause a noticeable vibration in the

vehicle. See the troubleshooting section at the end of

these instructions.

WARNING

DO NOT combine suspension, body, or other lift

devices. Use of vehicle with combined lifts may result

in unsafe and/or unexpected handling characteristics.

NOTE

Lift height may vary depending on vehicle configura-

tion, engine size, additional accessories, the factory

suspension package, and vehicle’s condition.

1 ‘05-’06 Frontier Leveling - Kit NL221

1 2 3 4 5 6

Summary of Contents

Page 1 - 2005-2006 KIT# NL221

2265 Crosswind Drive • Prescott, AZ 86301(928) 636-3175 • www.p-a-g.netNISSAN FRONTIERFRONT LEVELING KITINSTALLATION INSTRUCTIONS2005-2006 KIT# NL221

Page 2 - Before Starting Installation

2 ‘05-’06 Frontier Leveling - Kit NL221Before Starting Installation1. Carefully read all warnings and instructions com-pletely before beginning.2. Ver

Page 3 - Install Front Leveling Kit

3 ‘05-’06 Frontier Leveling - Kit NL221Engine Compartment1. Disconnect both battery cables. Disconnect negativecable first, then positive cable.Prepar

Page 4

4 ‘05-’06 Frontier Leveling - Kit NL221a. Scribe alignment mark lengthwise along upperplate, coil spring, and shock for proper re-assembly.b. Using co

Page 5

5 ‘05-’06 Frontier Leveling - Kit NL221g. Align marks on coil spring, upper plate, andshock. Install upper plate, shock, bushing,washer, and nut onto

Page 6 - After Completing Installation

6 ‘05-’06 Frontier Leveling - Kit NL221After Completing InstallationEngine Compartment1. Connect both battery cables. Connect positive cablefirst, the

Comments to this Manuals

No comments

Nissan Frontier Front Leveling Kit NL221 User Manual

Browse online or download User Manual for For the car Nissan Frontier Front Leveling Kit NL221. NISSAN Frontier Front Leveling Kit NL221 User Manual

Summary of Contents

Comments to this Manuals

Related products and manuals for For the car Nissan Frontier Front Leveling Kit NL221